Index Page Find us on Facebook  Find us on twitter  Follow our RSS Feed
It is currently Wed Oct 18, 2017 4:05 pm

All times are UTC [ DST ]




Post new topic Reply to topic  [ 23 posts ]  Go to page 1, 2  Next
Author Message
PostPosted: Sun Mar 16, 2014 12:04 am 
Offline
FSi Donator
FSi Donator

Joined: Mon Mar 19, 2007 12:29 pm
Posts: 3227
Location: Melbourne, derbyshire
Drives: Fiesta Shed mk6
Bought this as a cheap Ford to run-around in for a few years

A heads up of the car

2000 Ford Puma Millenium limited edition 1.7
81k miles
Zinc Yellow Paint
Leather recaro interior
Heated Front and Rear Screens
Air Con
CD
RCL
Leccy windows

Bought the car cheap cause of the usual ford puma problems, which are some arch rust some wear on the drivers seat, bit of an exhaust leak and probably not been serviced for a while, but its something different from the norm

Anyway here is said car

Image

Image

You can probably see the tape on the seat, woopy do lol

One of the mirrors was a boggo job, so I got a panther black one put on to match up the other

Image

Ive performed a service on the car for now, oil filter and sump plugs were a pain but were persuaded and new items fitted after an engine flush. All new helix oil on offer gone in with new fuel filter and new spark plugs, which was interesting.
The cam cover has obviously been leaking (common fault) spark plug are had quite a bit of oil in so cleaned this out at the same time, that is after drilling the bolts for the engine cover which had been done up stupid tight so rounded off when trying to remove :thumbsup:

Image
Oil soaked up

Image
Old vs new + oil lol

Image
During service

Image
Stupid button bolts had to be drilled :( £35 for ford replacements, B&Q will be £5 :thumbsup:

Image
Off until said bolts are bought and other plans underway

Oh and got this problem thanks to some bad roads heading home, got a leg coming Monday to swap this out :bs:
Image

Anyway, next will be timing belt, water pump, crankshaft oil seal and rocker cover sealant and gasket

After that sort the exhaust out ready for MOT and get it all waxoyled and arch liners sorted

separate from this probably turn the wheels grey or black, derestrict the airbox and replace for a panel filter

Then just run it, maybe get the seat fixed lol

_________________
Image
FACT wrote:
Ford is not a decision you make to like, its a passion you grow up with.

Image


Last edited by Mole259 on Mon May 19, 2014 7:19 pm, edited 1 time in total.

Top
 Profile  
Reply with quote  
PostPosted: Sun Mar 16, 2014 7:46 pm 
Offline
Elite FSI Poster
Elite FSI Poster
User avatar

Joined: Wed Sep 10, 2008 1:21 pm
Posts: 1284
Location: Aberdeen, Scotland
Nice motor mate :thumbsup:
Looks like once these little bits are done she'll be a good daily :)

Paul


Top
 Profile  
Reply with quote  
PostPosted: Mon Mar 17, 2014 9:25 am 
Offline
The Sherminator!
The Sherminator!

Joined: Sun Mar 06, 2005 6:10 pm
Posts: 22211
Location: Somewhere
not bad cars these!

shame you've had a few issues after buying it :cry:


Top
 Profile  
Reply with quote  
PostPosted: Mon Mar 17, 2014 10:57 am 
Offline
Elite FSI Poster
Elite FSI Poster
User avatar

Joined: Sun Dec 09, 2007 6:18 pm
Posts: 3409
Location: West Sussex. Drives: Too many man sized cars!!
Drives: Sideways
:thumbsup:

Private plate I see. Presume you kept "ADE"?

_________________
AUTOBAHNSTORMERS
Some people are like slinkies. Not really good for anything, but bring a smile to your face when pushed down the stairs!
ImageImageImage
From the moment I picked up your book until I laid it down, I was convulsed with laughter. Some day I intend reading it.


Top
 Profile  
Reply with quote  
PostPosted: Mon Mar 17, 2014 12:14 pm 
Offline
FSi Donator
FSi Donator

Joined: Mon Mar 19, 2007 12:29 pm
Posts: 3227
Location: Melbourne, derbyshire
Drives: Fiesta Shed mk6
woodsy_mv6 wrote:
:thumbsup:

Private plate I see. Presume you kept "ADE"?


Yup put it on retention which isn't cheap but didn't want to lose it

Hopefully sell this plate at some time someone with an L200 should want it :thumbsup:

_________________
Image
FACT wrote:
Ford is not a decision you make to like, its a passion you grow up with.

Image


Top
 Profile  
Reply with quote  
PostPosted: Fri Mar 21, 2014 8:10 am 
Offline
Southern Events Co-Ordinator
Southern Events Co-Ordinator
User avatar

Joined: Sat Apr 08, 2006 7:54 pm
Posts: 19046
Location: Didcot, Oxfordshire
Drives: Millennium Puma
Nice car mate ;)

_________________
Image

FACT wrote:
Ford is not a decision you make to like, its a passion you grow up with.


RIP BEN ELVIN (JAM) 6.6.84 - 3.10.12 - Gone but not forgotten - The below sums you up chap
Ben Elvin "Jam" wrote:
Through serious illness you meet some inspiring and determined people. its the best we can do as human beings to inspire and drive the determination of others. Ben.


Top
 Profile  
Reply with quote  
PostPosted: Sun Mar 23, 2014 1:27 pm 
Offline
FSI Supporter
FSI Supporter
User avatar

Joined: Thu May 19, 2005 6:23 pm
Posts: 2861
Location: Oswestry, salop
Drives: Shitroen VTS
Nice project. Are the seats the same as the fiesta?

like these?

http://www.ebay.co.uk/itm/ford-fiesta-f ... 4d1a8b0fa9

_________________
Image
snap, crackle, pop, crazy crazy world
www.Scartgamer.com


Top
 Profile  
Reply with quote  
PostPosted: Sun Mar 23, 2014 7:50 pm 
Offline
Northern Events Co-Ordinator
Northern Events Co-Ordinator
User avatar

Joined: Tue Jul 17, 2007 9:53 pm
Posts: 8545
Location: Sheffield
Drives: Mk1 FRS and FRST
Nice car bud :thumbsup:

_________________
Image


Top
 Profile  
Reply with quote  
PostPosted: Fri Mar 28, 2014 5:15 pm 
Offline
FSi Donator
FSi Donator

Joined: Mon Mar 19, 2007 12:29 pm
Posts: 3227
Location: Melbourne, derbyshire
Drives: Fiesta Shed mk6
Op wrote:
Nice project. Are the seats the same as the fiesta?

like these?

http://www.ebay.co.uk/itm/ford-fiesta-f ... 4d1a8b0fa9


No the seats are bespoke leather recaros :thumbsup: ill link a pic in of the interior as weather means no photos lol

Image

Dave G fsi wrote:
Nice car bud :thumbsup:


Cheers Dave :)

Gotta get this exhaust done and tempted to do the whole system as I need 2 of the three parts doing but im looking at £135 for the whole thing, doesn't sound much but on a runabout not so good

After this im gonna seal the whole underside and that should be it for the time being, possibly rattle can my wheels black and other cheap cheap stuff but now its had its bushes and suspension sorted its much much better :thumbsup:

_________________
Image
FACT wrote:
Ford is not a decision you make to like, its a passion you grow up with.

Image


Top
 Profile  
Reply with quote  
PostPosted: Fri Mar 28, 2014 8:00 pm 
Offline
David Dickinson's Naughty Bit
David Dickinson's Naughty Bit
User avatar

Joined: Mon May 25, 2009 9:08 pm
Posts: 8806
Location: Bournemouth
Drives: Fiesta ZS
They're good seats, worth a pretty penny too.
If you get rid of it and break it i'll probably take the engine :P you'll make your money back on the seats and engine, these are always a good investment in that respect.

They're also strangely nice looking cars even though they're bright yellow :lol:

_________________
Image

Image


Top
 Profile  
Reply with quote  
PostPosted: Sun Mar 30, 2014 9:27 am 
Offline
Out of the closet
Out of the closet

Joined: Thu Jul 23, 2009 1:40 am
Posts: 6276
Location: Southport
Drives: Ash Black Fiesta si 1.4
ahh this is the daily! very nice mole. seats look brilliant

_________________
Image
fifi


Top
 Profile  
Reply with quote  
PostPosted: Sun Mar 30, 2014 11:41 am 
Offline
FSI Supporter
FSI Supporter
User avatar

Joined: Sun Aug 03, 2008 11:20 am
Posts: 8463
Location: Rochdale
Drives: Si 1.6 & ST170
Those seats are great, I will probably one of the few that thinks the yellow is good haha.

_________________
Image
The Loumiester wrote:
Ford is not a decision you make to like, its a passion you grow up with.


Top
 Profile  
Reply with quote  
PostPosted: Mon Mar 31, 2014 9:13 am 
Offline
Southern Events Co-Ordinator
Southern Events Co-Ordinator
User avatar

Joined: Sat Apr 08, 2006 7:54 pm
Posts: 19046
Location: Didcot, Oxfordshire
Drives: Millennium Puma
black/dark wheels required!

_________________
Image

FACT wrote:
Ford is not a decision you make to like, its a passion you grow up with.


RIP BEN ELVIN (JAM) 6.6.84 - 3.10.12 - Gone but not forgotten - The below sums you up chap
Ben Elvin "Jam" wrote:
Through serious illness you meet some inspiring and determined people. its the best we can do as human beings to inspire and drive the determination of others. Ben.


Top
 Profile  
Reply with quote  
PostPosted: Sat Apr 05, 2014 4:13 pm 
Offline
Out of the closet
Out of the closet

Joined: Thu Jul 23, 2009 1:40 am
Posts: 6276
Location: Southport
Drives: Ash Black Fiesta si 1.4
my multispokes would look good on it ;)

_________________
Image
fifi


Top
 Profile  
Reply with quote  
PostPosted: Tue Apr 15, 2014 12:56 pm 
Offline
FSi Donator
FSi Donator

Joined: Mon Mar 19, 2007 12:29 pm
Posts: 3227
Location: Melbourne, derbyshire
Drives: Fiesta Shed mk6
bensouthport wrote:
my multispokes would look good on it ;)


Feck it im tempted by black steelies, saw some on a millennium lowered and looked sick

Im contemplating not getting rid ever, slag it on the cheap and when I get my new house ill get something better or just share a car with emma etc to bung my plates back on!

Just ordered a full suspension kit for the car brand new was so cheap just seemed like an idea seeing as ittl kill its dampers with just some springs on it, gonna order an exhaust too and some cheap wishbones ready for MOT time :thumbsup:

_________________
Image
FACT wrote:
Ford is not a decision you make to like, its a passion you grow up with.

Image


Top
 Profile  
Reply with quote  
PostPosted: Tue Apr 15, 2014 2:49 pm 
Offline
Southern Events Co-Ordinator
Southern Events Co-Ordinator
User avatar

Joined: Sat Apr 08, 2006 7:54 pm
Posts: 19046
Location: Didcot, Oxfordshire
Drives: Millennium Puma
nice one :)

as you know I am a fan of the pooma

_________________
Image

FACT wrote:
Ford is not a decision you make to like, its a passion you grow up with.


RIP BEN ELVIN (JAM) 6.6.84 - 3.10.12 - Gone but not forgotten - The below sums you up chap
Ben Elvin "Jam" wrote:
Through serious illness you meet some inspiring and determined people. its the best we can do as human beings to inspire and drive the determination of others. Ben.


Top
 Profile  
Reply with quote  
PostPosted: Wed May 07, 2014 9:47 pm 
Offline
FSi Donator
FSi Donator

Joined: Mon Mar 19, 2007 12:29 pm
Posts: 3227
Location: Melbourne, derbyshire
Drives: Fiesta Shed mk6
An update,

I'm on my annual leave now, early I know but my slot in the yearly leave set for us , so im using some of the time on the car to get it upto scratch

Ive had a few bits through the mail to add to the stock of parts I have, for instance new bushes, and a new clutch was £40 so seemed rude not to seeing as it is hasn't been replaced!

Image
Image
Image

Also received a new exhaust system and Cat for my old rusty one, which had to be part hammered and part disc cutted off as the nuts (tension) were beyond any use!
The new exhaust is only Aluminiumised Steel not surprising as it was so cheap, but incorporates a race tube, and ive coated it a few times in heat tape to help stop it rusting as quickly!

Image
Image
One exhaustless car
Image

The underneath, I've seen worse but you can probably see the OSR chassis and body is worse than the rest, ive set about sanding all the rust down that I can get to and kill rusting bad areas and then painting with either spray around certain parts, and/or hammerite waxoyl around the rest, especially the arches to hopefully stop anymore rust for a while, the arch liners were all but knackered, and im half tempted to not save them and just chuck them away, ill see how I feel!

Before
Image
Image

Old shocks off
Image

After

Image
Image
Image

Drums sanded down

Image

Painted

Image

Also have done 1 of the wheels to see how I got on with it, not done to bad for my own work!

Image
Image
Image
Image
Image
Image

And on the car

Image

Also The new shock kit, albeit a pain with no clear direction has been taking shape

Image

Handy place for a metal attachment right over the strut mount :doh:

Image

Image
Image
Image

That is all for now! More to come in time :thumbsup:

_________________
Image
FACT wrote:
Ford is not a decision you make to like, its a passion you grow up with.

Image


Top
 Profile  
Reply with quote  
PostPosted: Wed May 07, 2014 9:57 pm 
Offline
David Dickinson's Naughty Bit
David Dickinson's Naughty Bit
User avatar

Joined: Mon May 25, 2009 9:08 pm
Posts: 8806
Location: Bournemouth
Drives: Fiesta ZS
Oooooh racetube.

Looking good!

_________________
Image

Image


Top
 Profile  
Reply with quote  
PostPosted: Thu May 08, 2014 7:53 am 
Offline
Elite FSI Poster
Elite FSI Poster
User avatar

Joined: Wed Sep 10, 2008 1:21 pm
Posts: 1284
Location: Aberdeen, Scotland
Nice tidy bit of progress there mate :thumbsup:


Top
 Profile  
Reply with quote  
PostPosted: Thu May 08, 2014 8:08 am 
Offline
Southern Events Co-Ordinator
Southern Events Co-Ordinator
User avatar

Joined: Sat Apr 08, 2006 7:54 pm
Posts: 19046
Location: Didcot, Oxfordshire
Drives: Millennium Puma
nice work mate!

do love the pooma

_________________
Image

FACT wrote:
Ford is not a decision you make to like, its a passion you grow up with.


RIP BEN ELVIN (JAM) 6.6.84 - 3.10.12 - Gone but not forgotten - The below sums you up chap
Ben Elvin "Jam" wrote:
Through serious illness you meet some inspiring and determined people. its the best we can do as human beings to inspire and drive the determination of others. Ben.


Top
 Profile  
Reply with quote  
Display posts from previous:  Sort by  
Post new topic Reply to topic  [ 23 posts ]  Go to page 1, 2  Next

All times are UTC [ DST ]


Who is online

Users browsing this forum: No registered users and 19 guests


You cannot post new topics in this forum
You cannot reply to topics in this forum
You cannot edit your posts in this forum
You cannot delete your posts in this forum
You cannot post attachments in this forum

Search for:
Jump to:  
cron